| Part number | cost | ||
| 1 | Rover Montego 2.0 litre turbo diesel car, preferably a runner | £120.00 | |
  |
|||
| 2 | Haynes Workshop Manual - Austin/Rover Maestro & Montego Diesel Engine | 1857 | £15.00 |
| 3 | Adapter plate/flywheel housing | LR96001 | £300.00 |
| 4 | N/S Engine mounting bracket | LR99001 | £31.48 |
| 5 | O/S Engine mounting bracket | LR99002 | £34.36 |
| 6 | Alternator bracket | LR98003 | £45.63 |
| 7 | Alternator adjusting link | LR01001 | £3.89 |
all items from Dudleigh Engineering
 (carriage is
extra) |
|||
| 8 | Flywheel from Sherpa Van (2.) litre diesel engine, circa 1990) | £25.00 | |
| 10 | Clutch unit from Sherpa van | ||
| 11 | Sump from Sherpa van | ||
| 12 | Starter from Sherpa van | ||
| all from scrap yard, prices negotiable | |||
| 13 | else new starter motor for diesel LDV from Lucas - a staggering price! | LRS678 | £169.94 |
| 14 | Timing belt | UGTB 1190 | £36.09 |
| 15 | Throttle cable | QNAM 7902 | £14.41 |
| 16 | Rear crankshaft oil seal | QAHU 2157 | £17.31 |
| 17 | Exhaust downpipe | UGEX 11015 | £41.58 |
| all from your local friendly Rover dealer |
|||
| 18 | Pilot bearing for input shaft from any bearing supplier - 17/8OD, 7/8"ID by ½" | KLNJ7/8-ZZ | £12.29 |
| 19 | Fuel filter | Champion L111 | £10.99 |
| 20 | Air filter | Champion W227 | £5.79 |
| 21 | Oil filter | Champion B103 | £6.29 |
| 22 | 6 litres of 10/40W engine oil, more if you use an oil cooler | £15.00 | |
| 23 | Thermostat & gasket | £5.00 | |
| 24 | 12 litres of antifreeze (33% mix) | £15.00 | |
| 25 | Fan belt (alternator drive belt) Below example of car fitment | QH-QBA0987 | £3.49 |
| Nissan Cherry 1.0, 1.3, 1.5 1981-91 | Halfords HB987a | £3.49 | |
| Nissan Sunny 1.2, 1.3 1973-83 | Halfords HB987a | £3.49 | |
| 26 | Flexiable 2¼" ERW exhaust tube (2m length!) | £18.00 | |
| 27 | 2 exhaust clamps 2¼" | £2.81 | |
| 28 | 4 Glow Plugs | NGK Y920R | £23.50 |
| all from your local car accessory shop | |||
| 28 | 15mm combination wrench | £4.92 | |
| 29 | 15mm bi-hex socket ½" drive | £4.00 | |
| 30 | Impact driver set | £9.25 | |
| all from local tool shop | |||
| 31 | Capillary thermostat switch (RS Components Ltd) | 561-460 | £15.00 |
| 32 | LR diesel engine mounting rubbers x2 | NRC 2052 | £10.00 |
| 33 | LR Series 3 top hoses x2 | £8.00 | |
| 34 | Selection of hose clips - various sizes | £12.00 | |
| 35 | Selection of drain pipe fittings for air ducting (from B&Q) | ||
| 36 | Temperature sensor for 300 TDi | AMR1425 | £8.00 |
Finished - all up and running.....
© Witts End
Systems 
2004 - All rights
reserved